自動混凝土攪拌車運行的幾條秘籍_行業資訊_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

關于自動混凝土攪拌車是如何控制車速的？

2021-01-11

降低自動攪拌車零件磨損需注意的問題！

2021-02-06

平口攪拌車配件怎么做防腐處理？

2021-06-07

自動混凝土攪拌機夜間行車的注意事項！

2020-11-26

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自動混凝土攪拌車運行的幾條秘籍

所屬分類：行業資訊發布時間：2021-11-13 來源：http://www.bosplumbing.com/ 瀏覽量：0

自動混凝土攪拌車是一種特別的工程車輛，與一般的工程車輛不太相同，假如操作不妥會(huì )引起翻車、液壓泵、馬達、減速機過快磨損乃呈現悶罐等結果。以下17條運行秘籍請混凝土攪拌司機牢記在心并應用于實際作業傍邊。

Automatic concrete mixer is a special engineering vehicle, which is different from general engineering vehicles. If it is not operated properly, it will cause rollover, rapid wear of hydraulic pump, motor and reducer, and even stuffy tank. The following 17 operation secrets should be kept in mind by the concrete mixing driver and applied to the actual operation.
自動混凝土攪拌車

起動攪拌車之前，應把攪拌筒操作手柄放在“中止”方位。

Before starting the mixer truck, put the operating handle of the mixing drum in the "stop" position.

自動混凝土攪拌車起動發動機后，應使攪拌筒在低速下滾動10分鐘擺布，使液壓油溫升到20℃以上后方可作業。

After the engine of the automatic concrete mixer is started, the mixing drum shall be rolled at low speed for 10 minutes to make the hydraulic oil temperature rise above 20 ℃.

自動混凝土攪拌車在露天停放時，裝料前應將攪拌筒回轉，將積水和雜物排出，以保證混凝土的質量。

When the automatic concrete mixer is parked in the open air, the mixing drum shall be rotated before loading to discharge ponding and sundries to ensure the quality of concrete.

自動混凝土攪拌車在運送混凝土時，要保證滑斗放置結實，防止因松動形成搖擺，在跋涉中打傷行人或影響其它車輛正常運轉。

When transporting concrete, the automatic concrete mixer shall ensure that the sliding bucket is placed firmly to prevent swinging due to looseness, injuring pedestrians or affecting the normal operation of other vehicles during trekking.

自動混凝土攪拌車裝運攪拌好的混凝土時，攪拌筒轉速為2-10轉/分，在運送過程中，平整路面上攪拌筒轉速保證在2-3轉/分，行進在側傾斜度大于50的路面，或擺布晃動較大的路面時，應中止攪拌旋轉，待路況好轉后再康復攪拌旋轉。

When the automatic concrete mixer transports the mixed concrete, the rotating speed of the mixing drum is 2-10 R / min. during the transportation, the rotating speed of the mixing drum on the flat road shall be 2-3 R / min. when traveling on the road with a side inclination greater than 50 or the road with large shaking, the mixing rotation shall be stopped, and the mixing rotation shall be resumed after the road conditions improve.

自動混凝土攪拌車運送混凝土的時刻不能超越攪拌站規則的時刻。運送混凝土途中，攪拌筒不得長時刻停轉，以防混凝土發生離析景象。司機應經常調查混凝土狀況，發現異常及時通報調度室，請求做出處理。

The time for automatic concrete mixer to transport concrete shall not exceed the time specified in the mixing station. During the transportation of concrete, the mixing drum shall not stop for a long time to prevent concrete segregation. The driver shall frequently investigate the concrete condition, timely report any abnormality to the dispatching room and ask for handling.

自動混凝土攪拌車車內裝有混凝土時，在現場阻滯時刻不得超越1小時，如超時應立即請求現場負責人給予及時處理。

When the automatic concrete mixer truck is loaded with concrete, the blocking time on site shall not exceed 1 hour. If it exceeds the time limit, it shall immediately request the on-site person in charge to deal with it in time.

自動混凝土攪拌車運送混凝土塌落度不得低于8cm。從混凝土入罐到排出，氣溫高時不得超越2小時有必要排出，陰雨氣候溫度低時，不得超越2.5小時。

The slump of concrete transported by automatic concrete mixer shall not be less than 8cm. From the concrete entering the tank to discharging, it shall not exceed 2 hours when the temperature is high, and it is necessary to discharge it. When the temperature is low in cloudy and rainy weather, it shall not exceed 2.5 hours.

自動混凝土攪拌車在排出混凝土之前，應使攪拌筒在10-12轉/分的轉速下滾動1分鐘，再進行排料。

Before discharging concrete, the automatic concrete mixer shall make the mixing drum roll at the speed of 10-12 rpm for 1 minute before discharging.

自動混凝土攪拌車出料結束，應立即用隨車的軟管放水將進料口、出料斗及出料溜槽等部位沖刷潔凈，排去粘結在車身各處的污物及殘留混凝土，再向攪拌筒內灌水150-200L的清水，在回來途中要讓攪拌筒慢速滾動，以清洗內壁，防止殘余料渣附在筒壁和攪拌葉上，并在再一次裝料前將這些水放掉。

After the discharge of the automatic concrete mixer truck, immediately flush the feed inlet, discharge hopper and discharge chute with the hose attached to the truck, discharge the dirt and residual concrete bonded to the vehicle body, and then fill the mixing drum with 150-200l clean water. On the way back, let the mixing drum roll slowly to clean the inner wall and prevent the residual slag from adhering to the cylinder wall and mixing blade, And drain the water before loading again.
自動混凝土攪拌車

自動混凝土攪拌車運送混凝土時，發動機轉速在1000-1400轉/分范圍內作業，以使發動機有扭距，在運送混凝土過程中，車速不得超越40km/h，以保行車。

When the automatic concrete mixer transports concrete, the engine speed shall be within the range of 1000-1400 rpm to make the engine have the maximum torque. In the process of transporting concrete, the speed shall not exceed 40km / h to ensure driving safety.

自動混凝土攪拌車作業結束，應把攪拌筒內部和車身清洗潔凈，不能使剩余的混凝土留在筒內。

After the operation of the automatic concrete mixer is completed, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.

自動混凝土攪拌車在水泵作業時，制止空轉，接連運用時不要超越15分鐘。

When the automatic concrete mixer works with the water pump, stop idling, and do not exceed 15 minutes during continuous operation.

混凝土攪拌車水箱的水量要經常堅持裝滿，以備急用，冬天停機后，應將水箱、水泵、水管、攪拌筒內的水放凈，并停放在向陽、不積水的當地，以免凍壞機械。

The water volume of the water tank of the concrete mixer truck shall always be filled for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum shall be drained and parked in a sunny place without ponding to avoid freezing the machine.

自動混凝土攪拌車在冬天應及時安裝保溫套，并運用防凍液對攪拌車加以維護，依據氣候變化替換燃油標號，保證機械的正常運用。

In winter, the automatic concrete mixer shall be installed with thermal insulation sleeve in time, and the mixer shall be maintained with antifreeze, and the fuel grade shall be replaced according to climate change to ensure the normal operation of the machinery.

在查看、修補水泥攪拌車液壓傳動部分時，應使發動機和液壓泵在沒有壓力的狀況下進行。

When inspecting and repairing the hydraulic transmission part of the cement mixer truck, the engine and hydraulic pump shall be operated without pressure.

在調整混凝土攪拌車各部空隙、行程、壓力時，應由專職員查看贊同;替換機件時，有必要由部長或主管司理簽字，不然呈現問題后追查有關人員職責。

When adjusting the gap, stroke and pressure of each part of the concrete mixer, it shall be checked and approved by the full-time safety officer; When replacing parts, it is necessary to sign by the minister or the competent manager, otherwise the responsibilities of relevant personnel will be traced after problems appear.

今天的自動混凝土攪拌車http://www.bosplumbing.com/知識就分享到這里了，感謝您的瀏覽，請點擊官網查看其他詳細內容。

Today's automatic concrete mixer http://www.bosplumbing.com/ That's all for knowledge sharing. Thank you for browsing. Please click the official website to view other details.

上一頁：混凝土攪拌車怎么保養省油？下一頁：全自動攪拌車多個舉措全力保障施工

熱門產品 / HOT PRODUCT