混凝土攪拌車做到行車需要做自身的調整嗎？_公司新聞_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

購買的混凝土攪拌車上裝如何正確的安裝調試？

2021-04-16

混凝土攪拌車的使用特點要掌握

2022-10-18

全自動上料攪拌一體車的結構有哪些?

2020-07-03

5方自動上料攪拌車整機無力故障

2021-08-06

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

混凝土攪拌車做到行車需要做自身的調整嗎？

所屬分類：公司新聞發布時間：2021-08-23 來源：http://www.bosplumbing.com/ 瀏覽量：0

、輸送混凝土的容量，質量及塌落度應符合混凝土行業標準和要求。

First, the capacity, quality and slump of transported concrete shall meet the concrete industry standards and requirements.

第二、在混凝土運輸過程中罐體禁止停轉，防止造成混凝土的凝結，停轉重啟時會(huì )造成對液壓系統、減速機的沖擊，導致液壓泵和馬達的損壞。

Second, it is forbidden to stop the tank during concrete transportation to prevent concrete condensation. When stopping and restarting, it will cause impact on the hydraulic system and reducer, resulting in damage to the hydraulic pump and motor.

第三、在公路上行駛時，加長溜槽必須放置在卸料溜槽支架上并用掛鉤掛牢，不允許掛在主排料溜槽上運行；主排料溜槽要旋轉到固定位置，拉下定位手柄，用鎖緊手柄將彈簧變幅機構鎖止，防止由于不固定而搖擺，造成傷人事故和影響其它車輛運行可能。

Third, when driving on the road, the extended chute must be placed on the support of the discharge chute and hung firmly with a hook. It is not allowed to hang on the main discharge chute for operation; The main discharge chute shall be rotated to a fixed position, the positioning handle shall be pulled down, and the spring luffing mechanism shall be locked with the locking handle to prevent swinging due to non fixation, causing injury accidents and affecting the operation of other vehicles.
自動混凝土攪拌車

第四、工作裝置連續運轉時間不應超過8h。

Fourth, the continuous operation time of the working device shall not exceed 8h.

第五、卸料時，如發現水分蒸發，塌落度偏低不能滿足用戶要求時，可適當向筒內加水，然后以10—14r/min的速度旋轉30轉后卸料，使混凝土充分攪拌。

Fifth, during unloading, if water evaporation and low slump are found, which can not meet the user's requirements, water can be added to the cylinder appropriately, and then rotate at the speed of 10-14r / min for 30 revolutions before unloading, so as to fully mix the concrete.

第六、攪拌車在空載運行過程中，攪拌筒不得停轉以免顛簸時造成滾道和托輪局部磕碰，導致托輪和滾道的異常損壞。

Sixth, during the no-load operation of the mixer truck, the mixing drum shall not stop running, so as to avoid local collision between the raceway and the supporting wheel during bumping, resulting in abnormal damage to the supporting wheel and the raceway.

第七、水箱的水量要經常加滿，以備急用。水箱加水前，必須打開放氣閥把箱內空氣放掉；沖洗時打開氣閥，沖洗完畢或者停用時應將水罐內氣體放掉。冬季停放時，水箱和供水系統里，不得有剩余水，防止凍裂。注意：水箱僅在供水時加壓，不要帶著加壓水箱在公路上行駛。

Seventh, the water tank should always be filled up for emergency use. Before adding water to the water tank, the vent valve must be opened to release the air in the tank; Open the air valve during flushing, and discharge the gas in the water tank after flushing or shutdown. When parking in winter, there shall be no residual water in the water tank and water supply system to prevent frost cracking. Note: the water tank is pressurized only when supplying water. Do not drive on the road with the pressurized water tank.

第八、滿載混凝土正轉，如要反轉，必須操縱手柄使正轉停穩后，再操縱手柄反轉。嚴禁正轉過程中操縱手柄使其反轉。

Eighth, full load concrete forward rotation, if you want to reverse, you must operate the handle to make the forward rotation stop stably, and then operate the handle to reverse. It is strictly prohibited to operate the handle to reverse it during forward rotation.

本文由自動混凝土攪拌車http://www.bosplumbing.com奉獻.更多有關的知識請點擊:真誠的態度.為您提供為的服務.更多有關的知識我們將會(huì )陸續向大家奉獻.敬請期待.

This paper is composed of automatic concrete mixer http://www.bosplumbing.com Dedication. For more relevant knowledge, please click: sincere attitude. Provide you with comprehensive service. More relevant knowledge will be offered to you one after another. Please look forward to it

上一頁：自動混凝土攪拌機粘度過高及機內有渣土要怎么處理？下一頁：自動混凝土攪拌車為什么會(huì )變得如此普遍了呢？

熱門產品 / HOT PRODUCT